company lawsuits

Suit over deadly crash renews spotlight on GM safety practices

Reuters

This is AI generated summarization, which may have errors. For context, always refer to the full article.

Suit over deadly crash renews spotlight on GM safety practices

WRECKAGE. The wrecked 2007 Chevrolet Trailblazer that resulted in a lawsuit renewing a spotlight on General Motors' safety practices is seen in this undated handout photo in Marietta, Georgia.

Photo from Lance Cooper/Reuters

Years after a car crash that killed a 42-year-old mother in the US, General Motors remains under scrutiny

On a clear afternoon in November 2014, Glenda Marie Buchanan set off in her silver Chevrolet Trailblazer SUV from her home in rural Georgia. Several minutes into the drive, she started veering off the road. Buchanan swerved left and lost control, and the vehicle rolled onto its side into a ditch.

The 42-year-old mother and Home Depot saleswoman died in the crash. The cause, her widower alleges in a lawsuit, was a defective steering sensor that the vehicle’s manufacturer, General Motors Company, failed to adequately warn drivers about despite long knowing the component had issues.

The sensor’s failure disabled the 2007 Trailblazer’s electronic stability control, a significant safety feature designed to prevent crashes, according to the lawsuit, which was filed in a local Georgia court in 2016 and updated in 2020. GM, the top-selling automaker in the United States, denies the allegations.

The case renews a spotlight on GM’s safety practices, 7 years after the Detroit automaker vowed never to repeat a notorious failure to recall millions of vehicles with defective ignition switches later linked to 124 deaths. The ongoing litigation alleges that GM long concealed problems with the steering sensor that risked creating dangerous conditions for drivers, even after an internal investigation uncovered issues with the component.

A Reuters review of hundreds of pages of documents submitted in the Buchanan litigation shows that GM has since 2007 confronted a series of issues with the steering sensor, including high levels of warranty claims and a manufacturing flaw, without recalling affected vehicles. Buchanan’s case is the only one Reuters has identified in which a death is alleged to have stemmed from a failure of the steering sensor.

Many of the key documents Reuters reviewed, including depositions taken of GM employees and findings from an internal GM probe in 2018, are filed under seal or otherwise shielded from public view under a Georgia judge’s sweeping protective order. Their contents are reported here for the first time.

The 2018 GM investigation into the steering sensor was launched after evidence in the Buchanan case suggested a problem with the component in her car. That probe found more than 73,700 warranty claims related to the part, according to a GM document and the deposition of a company employee. The documents don’t detail the specific issues raised in the warranty claims. GM declined to comment on the claims.

The number of claims is equal to about 10% of the roughly 778,000 SUVs GM manufactured with the sensor between 2006 and 2009. Car companies usually expect a rate of defects or other problems among vehicle components closer to a fraction of 1%, according to industry advisers. About a half a million vehicles containing the component remain on US roads, according to 2019 registration data from digital automotive marketing firm Hedges & Company.

GM decided against recalling vehicles after the internal probe found it inconclusive as to whether electronic stability control was inoperative at the time of Buchanan’s crash, according to employee testimony reviewed by Reuters. The probe made no determination on whether the sensor was defective.

The sensor is a key part of GM’s version of electronic stability control, called StabiliTrak. Like other such systems, StabiliTrak adjusts brakes and engine power to help drivers avoid losing control and crashing.

Both GM and regulators have lauded electronic stability control as among the most significant automotive safety features since the seatbelt. A 2007 US safety regulation has made the life-saving feature mandatory in almost all new vehicles since September 2011. It saved more than 7,000 lives during the 5-year period from 2011 to 2015, according to regulators.

The primary US vehicle safety regulator, the National Highway Traffic Safety Administration (NHTSA), told Reuters it reviewed concerns raised by Lance Cooper, the lawyer representing Buchanan’s widower. In a February 2020 letter to NHTSA, Cooper urged regulators to investigate GM for failing to disclose the allegedly defective steering sensor in a timely manner and recall affected vehicles. Cooper previously unearthed evidence in another case that helped set off GM’s ignition-switch crisis.

But NHTSA said it decided in late January against opening an investigation. That previously unreported review included confidential documents related to the litigation that GM provided to the agency in March of last year, in response to an informal request for information, according to court documents.

The NHTSA review “determined there was insufficient evidence to lead to a formal investigation at this time,” the agency said, adding that it would take future action if warranted. The agency noted that the SUVs containing the steering sensor were built before almost all new vehicles sold in the United States were required to come equipped with electronic stability control.

In written responses to questions from Reuters, GM said that after the ignition-switch crisis, it “comprehensively rebuilt and strengthened its product safety processes.” That includes encouraging employees to elevate concerns, the company said. GM also underwent several years of extra oversight from regulators. It declined to comment on NHTSA’s decision to not open an investigation.

Asked about the alleged issues with the steering sensor and GM’s decision to not recall vehicles, the automaker said it had conducted thorough investigations involving experts across many disciplines. After “a rigorous analysis of internal and external data,” the company said, “we’re not aware of any other complaints alleging accidents,” aside from Buchanan’s, that involve StabiliTrak disengaging due to a faulty steering sensor.

The sensor-related data scrutinized in GM’s 2018 investigation included the warranty claims as well as 3 other legal claims and more than 5,800 complaints from dealers and customers. GM declined to comment on the complaints and the volume of claims.

On the Buchanan crash, GM said that a warning light in the vehicle had flashed hundreds of times before her fatal journey, indicating service was required. Current and former GM employees testified that even after losing StabiliTrak, drivers can still steer and brake, so vehicles remain safe.

GM, in a court filing, has denied that the sensor in Buchanan’s vehicle failed and disabled StabiliTrak. Buchanan was texting minutes before the crash on a dangerous roadway replete with winding curves and narrow shoulders, GM said in another court filing. Buchanan was also driving 5 to 10 miles per hour above the posted speed limit, GM said in the court filing, pointing to testimony of a woman who was driving behind her for several miles before the crash.

The widower’s lawyer, Cooper, countered GM’s account of the crash in a court filing, saying phone records show she wasn’t texting at the time of the wreck and disputing that the road was dangerous. Cooper told Reuters that the Trailblazer’s black box did not record her speed.

GM is fighting an attempt by Cooper to depose its chief executive, Mary Barra. In a sworn affidavit, Barra has said she knew nothing about the automaker’s inquiry into the steering sensor. Barra, via the company spokesman, declined an interview request.

GM noted the vehicles containing the component were built more than a decade ago. The GM models containing the steering sensor are the 2006-2009 Trailblazer and GMC Envoy; 2006-2007 Buick Rainier; 2006-2009 Saab 9-7x; and 2006-2007 Isuzu Ascender, according to court records.

TOP BOSS. General Motors CEO Mary Barra attends the annual Allen and Co. Sun Valley media conference in Sun Valley, Idaho, July 12, 2019.
Photo by Brendan McDermid/Reuters
‘Déjà vu’

Two former heads of NHTSA questioned GM’s decision not to launch a recall. They told Reuters they would expect a vehicle manufacturer to conduct a recall when presented with evidence of high warranty claims related to the same component, such as those GM found with the steering sensor, and a condition that risks disabling a key safety feature like electronic stability control.

The two former NHTSA heads also questioned the agency’s decision not to open an investigation. One of them is David Friedman, who was acting head of NHTSA during GM’s ignition-switch crisis. Friedman said he would have expected the agency to do more because the technology, even if not required, was well on its way to becoming mainstream when the affected vehicles were built. GM began including StabiliTrak as a standard feature in the Trailblazer and other similar SUVs in model year 2006, 5 years before it became mandatory.

“Taking it away makes the car more dangerous, and that’s likely an unreasonable risk to safety,” Friedman said, adding that he believed it warranted further investigation. “Imagine if your seatbelts, before seatbelts were required, didn’t work.” Cooper expressed disappointment with NHTSA’s decision, saying the risk of sensor failure “unquestionably relates to automotive safety.”

NHTSA said it reviewed all available data “for severity of outcome and verified frequency of occurrence” related to the sensor before deciding not to pursue a formal probe. The agency said it would continue to monitor complaints and other data.

GM said it reported Buchanan’s claims to NHTSA after the lawsuit was filed in 2016 under legal obligations requiring automakers to disclose the existence of such incidents and allegations.

US law requires car companies to alert regulators within 5 days of discovering a vehicle defect that poses an unreasonable safety risk, which includes conditions increasing the chance of a crash or a component malfunctioning that could harm consumers. Manufacturers must then recall affected vehicles.

The maximum fine for compliance failures is about $100 million, a small fraction of the billions of dollars in annual sales for many large automotive companies. Criminal liability for failing to disclose a safety defect is limited under federal law, so prosecutors looking to bring charges usually need to pursue other allegations, such as illegal coverups or fraud.

Regulators cracked down 7 years ago on automotive companies skirting legal requirements to disclose safety risks. Yet manufacturers still have significant leeway in deciding how to address concerns in vehicles, including whether a problem is serious enough to launch a recall, according to industry advisers and former US officials.

The term “defect” is not narrowly defined under US law, leaving it open to debate, including over the likelihood of a problem harming drivers. But even a remote chance of injury can trigger recalls, industry advisers and former US automotive safety officials said.

GM has in the past recalled other vehicles with conditions that risked disabling electronic stability control.

Cooper told Reuters that GM’s approach to the alleged sensor issues drew parallels with the automaker’s years-long scramble to make sense of concerns related to vehicles with defective ignition switches before launching a recall.

“It’s déjà vu,” Cooper said.

GM previously admitted it kept regulators and consumers in the dark about the faulty ignition switch despite clear internal evidence it could lead to dangerous airbag failures. In 2015, GM resolved criminal charges stemming from the lapse in a deferred prosecution agreement. In its responses to Reuters, the automaker rejected Cooper’s ignition-switch comparison and said concerns raised in the Buchanan case were subjected to “robust” investigation.

The component at issue monitors the steering wheel’s position and is part of the StabiliTrak system. According to a Reuters analysis of NHTSA consumer complaint data, regulators have received more than 100 complaints concerning the sensor or StabiliTrak in vehicles with the component over the past 15 years. That included one complaint involving a crash in 2014, alleging StabiliTrak operated when it shouldn’t have. If electronic stability control activates at the wrong time, the system could suddenly apply brakes, potentially causing a driver to lose control of the vehicle.

The complaints include reports of steering sensors malfunctioning, StabiliTrak warning lights illuminating, and StabiliTrak being disabled or improperly activating. More than 30 of the complaints involved consumers allegedly losing control of their vehicles.

A complaint is not dispositive evidence of sensors or StabiliTrak malfunctioning, however. Complaints often lack key details or have varying amounts of information, which limits regulators’ ability to pinpoint specific problems.

GM declined to comment on Reuters’ analysis of the NHTSA data. But it said its experts usually cast a wide net when reviewing such consumer complaints early in investigations before zeroing in on information deemed more precisely related to the issue under scrutiny. A crash involving StabiliTrak improperly activating is distinct from allegations in the Buchanan case that the system disengaged, GM said.

GM CASE. Lance Cooper, founding partner of The Cooper Firm, poses for a portrait in his office in Marietta, Georgia, March 4, 2021.
Photo by Elijah Nouvelage/Reuters
Manufacturing anomaly

GM began including StabiliTrak as a standard feature in the Trailblazer and the other similar SUVs in model year 2006.

Issues with the steering sensor soon arose. In 2007 model-year vehicles, warranty claims related to the component increased to a high level, according to a February 2020 deposition of Mario Kennedy, a long-standing GM engineer who worked on electronic stability control. That increase, in part, prompted a GM problem-solving team to study the sensor, he said.

Kennedy testified that a batch of steering sensors on the 2007 Trailblazer and other similar vehicles had a “manufacturing anomaly.” The nature of the anomaly is unclear from Kennedy’s testimony because the transcript reviewed by Reuters is heavily redacted. But he said GM fixed it.

Kennedy, now retired from GM, couldn’t be reached for comment.

Cooper told Reuters the anomaly related to improper metal coating applied to the sensor. An expert for Cooper has since determined the coating problem likely didn’t affect Buchanan’s sensor, though it hasn’t been ruled out, the lawyer said.

In 2008, several wiring-related issues contributed to high levels of warranty claims potentially related to the steering sensor, Kennedy said in his deposition. GM instructed dealerships on how to fix them, Kennedy testified.

GM declined to comment on the volume and nature of the claims.

LEGAL BATTLE. Robert Randall Buchanan poses for a portrait at his home in Douglasville, Georgia, March 4, 2021.
Photo by Elijah Nouvelage/Reuters
Trouble code

Glenda Marie Buchanan purchased her previously-owned 2007 Chevrolet Trailblazer 3 years before her crash. Her widower said in an interview that she chose a Trailblazer partly because it was a bigger, heavier car that they thought would be safe.

On the afternoon of the November 2014 crash, she had been on her way to pick up a dessert from a nearby house, her widower, Robert Randall Buchanan, told Reuters. Before the accident, she appeared to be driving normally, the woman following behind her on the road testified.

Buchanan was wearing a seatbelt, according to a police report and her widower’s complaint.

In March 2018, as part of the case, a GM supplier downloaded data from the vehicle’s electronic brake control module with experts for Cooper and GM present. It showed the presence of a trouble code that indicates a malfunctioning steering wheel angle sensor or problems with electronic signals coming from the component, according to Kennedy’s testimony and GM.

The supplier that conducted the download, now part of ZF Friedrichshafen AG, declined to comment.

The code’s presence causes StabiliTrak to deactivate, according to employee testimony and GM. One reason StabiliTrak disables under that condition is to prevent it from unsafely activating when it is not supposed to, according to Kennedy’s testimony and GM.

A few months later, in June 2018, GM opened its internal investigation. A member of the automaker’s legal department had alerted colleagues to the Buchanan case via a program its chief executive created after the ignition-switch crisis to elevate concerns, according to employee depositions and other documents.

The GM investigator leading the probe, Christa Zilincik, found the automaker had received 73,711 warranty claims related to the steering wheel angle sensor as of mid-July 2018, according to her testimony and a document reviewed by Reuters.

GM’s probe also identified 5,861 complaints from customers or dealers plus 59 complaints to regulators related to the sensor, Zilincik testified. The documents don’t detail the nature of the complaints, and GM declined to comment on them.

Two GM committees reviewed Zilincik’s findings and decided against recalling affected vehicles, she testified. Zilincik couldn’t be reached for comment.

Dan Sharkey, a Detroit-area automotive industry lawyer who isn’t involved in the Buchanan case, said GM’s findings could not be ignored. The volume of warranty claims amounting to roughly 10% of vehicles built with the component that GM uncovered is “materially high,” he said. “That’s enough where you would say, ‘We’ve got a big problem here.'” – Rappler.com

Add a comment

Sort by

There are no comments yet. Add your comment to start the conversation.

Summarize this article with AI

How does this make you feel?

Loading
Download the Rappler App!